Why choose TPO for a flat roof in Arkansas?
TPO is a tough, rubber-like membrane made for flat roofs. We heat-weld the sheets into one sealed surface, so there is almost nothing for water to get through. It is white, so it reflects the Arkansas sun instead of soaking it up.
Shingles do not belong on a flat roof. Water sits there instead of running off, and shingles need slope to work.
Here is how flat roof options compare.
| Flat roof type | How long it lasts | Seams |
|---|---|---|
| TPO membrane | 20–30 years | Heat-welded, sealed |
| Modified bitumen | 15–20 years | Torched or glued |
| Built-up (tar and gravel) | 15–25 years | Many layers |
How much does a TPO flat roof cost in Hot Springs?
It depends on three things: the square footage, what sits on the roof, and whether the old roof comes off first. A small porch prices out very differently than a shop roof covered in vents. We measure your roof for free and put the number in writing.
Here is what drives the cost:
- Square footage. Bigger roof, more membrane and labor.
- What is on the roof. Vents, pipes, and HVAC units each need flashing by hand.
- Tear-off or overlay. If the old roof is soaked, it comes off first.
Wet insulation under an old membrane is common. We check for it before we quote.
What does a TPO install look like?
We strip the old roof, check the decking, and lay down insulation board. Then we roll out the TPO membrane and heat-weld every seam into one sheet. Flashing goes around each vent and edge last.
Most flat roofs take two to four days. Weather matters. We do not weld membrane in the rain.
You get a walk-through when we finish, and we show you the seams.
Why does my flat roof keep leaking?
Flat roofs leak because water sits on them. Ponding water works into any weak seam, old patch, or worn flashing. Once a membrane is at the end of its life, patching one spot just moves the leak.
Look for these warning signs.
| What you see | What it means |
|---|---|
| Puddles two days after rain | Bad slope or clogged drain |
| Bubbles or ripples | Water trapped under membrane |
| Cracked, chalky surface | Membrane is worn out |
| Stains on your ceiling | Active leak, act now |
If you have an active leak, our roof leak repair crew can find it and stop it.
Do you do TPO on commercial buildings?
Yes. TPO is the go-to for shops, offices, and small commercial buildings across Garland County. We can often work around your business hours.
We are licensed in Arkansas, license number RR0540931024, and we are based at 209 Albert Pike in Hot Springs. Our own crews do the work. We do not hand your job to a subcontractor.
Where do you install flat roofs?
We serve Hot Springs and the surrounding area, including Benton, Bryant, Malvern, and Pine Bluff. Our Pine Bluff line is 870-335-2611.
Financing is available if you would rather not pay all at once. See our financing page for details.
Ready for a free flat roof inspection? Contact us or call 501-359-5550, seven days a week.
Frequently asked questions
What is TPO roofing?
TPO is a tough, rubber-like membrane made for flat and low-slope roofs. It rolls out in wide sheets that we heat-weld together, so there are almost no seams for water to find. It is white, which reflects the Arkansas sun and keeps your building cooler.
How much does a TPO flat roof cost in Hot Springs?
Three things drive your price. Square footage, how many vents and units sit on the roof, and whether the old roof needs a full tear-off all move the number. Wet insulation underneath is common here, and it changes the job. We measure your roof for free and give you a written number.
How long does a TPO roof last?
A TPO roof lasts 20 to 30 years when it is installed right and checked now and then. The membrane itself holds up well to Arkansas heat and rain. Most failures start at seams or flashing, which is why we heat-weld every seam.
Why does my flat roof keep leaking?
Flat roofs leak because water sits instead of running off. Ponding water finds any weak seam, old patch, or bad flashing around a vent. A patch job on top of a worn membrane rarely holds. A new TPO membrane fixes the whole surface at once.
Is a flat roof really flat?
No. Every good flat roof has a slight slope so water drains toward gutters or drains. If yours holds puddles two days after rain, the slope or the drains are the problem. We check drainage on every inspection before we quote you.
Can you install TPO on my commercial building?
Yes. TPO is the most common choice for shops, offices, and small commercial buildings in Hot Springs. We work around your hours where we can. Call 501-359-5550 and we will come measure the roof and talk through the schedule.